Product ID:SILICONE ALKYD COPOLYMER ENAMEL, 17178 SILVER
MSDS Date:03/01/1997
FSC:8010
NIIN:00N091611
Status Code:A
MSDS Number: CJMMV

Emergency Phone: 206-244-8844

Info Phone: 800-727-9694

Cage: 6F266

Telephone: 206-244-8844

Cage: 6F266

LIGROINE; (MINERAL SPIRITS 350)

CAS: 8032-32-4

RTECS: OI6180000

OSHA PEL 100 PPM

ACGIH TLV: 1370 MG/M3;300 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: THIS MATERIAL MAY CAUSE
IRRITATION, SENSITIZATION, OR DEFATTING OF SKIN UPON PROLONGED OR
REPEATED CONTACT. INHALATION: EXCESSIVE EXPOSURE TO VAPORS OR SPRAY
MIST CAN RESULT IN HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
CONSCIOUSNESS. SOME REPORTS HAVE ASSOCIATED REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. EYES: THIS MATERIAL M AY BE AN EYE IRRITANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTION. (SEE SAFE HANDLING AND USE INFORMATION
SECTION)

First Aid:SKIN: PROMPTLY WASH WITH SOAP AND WATER. REMOVE AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH WITH LARGE
QUANTITIES OF WATER FOR AT LEAST 15 MINUTES AND SEEK MEDICAL
ATTENTION. INGESTIO N: IF INGESTED DO NOT INDUCE VOMITING; KEEP
PERSON WARM AND QUIET AND GET MEDICAL ATTENTION. ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUM WHICH CAN BE FATAL.
INHALATION: REMOVE VICTIM TO FRESH AIR IMMEDIATELY. IF RESPIRATORY
SYMPTOMS DEVELOP, SEEK MEDICAL ATTENTIONAT ONCE.

Flash Point Method:TCC
Flash Point:=41.7C, 107.F
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE ABOVE OR ANY CLASS B EXTING EXTINGUISHING AGENT.
WATER MAY BE UNSUITABLE AS EXTING MEDIUM, BUT HELPFUL IN KEEPING
ADJACENT CONTAINERS COOL .
Unusual Fire/Explosion Hazard:FLAMMABILITY CLASSIFICATION: OSHA:
COMBUSTIBLE; CLASS 3. VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN AIR
AND MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED CONTAINERS
MAY RUPTURE WHEN EXPOSED TO EXTR EME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. VENTILATE AREA.
ABSORB SPILL WITH ABSORBENT MATERIAL SUCH AS SAWDUST, VERMICULITE
OR SAND AND PLACE MATERIAL INTO CLOSED CONTAINER. IF LARGE SPILL,
DIKE AREA TO PREVENT TH IS MATERIAL FROM ENTERING WATER SYSTEMSOR
SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.

Handling and Storage Precautions:AVOID PROLONGED OR REPEATED INHALATION
OF HEATED VAPORS OR SPRAY MIST. KEEP AWAY FROM HEAT OR OPEN FLAME.
THIS MATERIAL MAY CAUSE SENSITIZATION. DO NOT GET IN EYES, ON SKIN
OR CLOTHING. DO NOT ALLOW C ONTAMINATED CLOTHING TO CONTACT SKIN.
Other Precautions:DO NOT WELD ON FULL OR EMPTY CONTAINERS. KEEP
CONTAINERS CLOSED WHEN NOT IN USE, AND PROPERLY LABELED.

Respiratory Protection:A NIOSH APPROVED CANISTER-TYPE RESPIRATOR MUST
BE WORN TO PREVENT THE INHALATION OF VAPORS OR SPRAY MIST WHEN THE
TLV OR PEL IS EXCEEDED.
Ventilation:GEN VENT IS REQD DURING NORMAL USE. LOC VENT MAY BE REQD
DURING CERTAIN OPERATIONS TO KEEP EXPOSURE LEVEL BELOW LIMITS
LISTED IN INGREDS.
Protective Gloves:CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER GLOVES
REQUIRED.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
PHYSICAL DATA: WT/GAL: 10.12 LBS. VOC: 340 GRAMS/LITER (LESS WATER).
WASTE DISP: LOCAL, STATE & FEDERAL AGENCIES. GROUND HNDLG EQUIP TO
PVNT SPKS. FOR FURTHER INFO: CONT STATE/LOC WASTE AGENCY/U.S.
ENVIRON PROT AGENCY'S RCRA HOTLINE (1-800-424-9346 OR
1-202-382-3000).

Boiling Pt:>152.8C, 307.F
B.P. Text:307-387F
Vapor Pres:2.6 MMHG @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.21
VOC Pounds/Gallon:340
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:WHITE LIQUID (OR COLOR OF TINT), MILD ODOR.
Percent Volatiles by Volume:45

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME. IF PRODUCT
CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONXIDE AND TOXIC VAPORS.

Waste Disposal Methods:WASTE DISP METH: IF DISCARDED, MATL & CNTNRS
SHOULD BE TREATED AS HAZ WASTE BASED ON CHARACT OF IGNITABILITY AS
DEFINED UNDER FED RCRA REGS (40 CFR 261). DISP OF MATL/ITS CNTNRS
REQS COMPLIANCE W/APPL ICABLE LBLG, PACKING & RECORDKEEPING STDS.
WASTE DISP: DISPOSE IN/A/W (SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT: COMBUSTIBLE. UN NUMBER: 1263.

SARA Title III Information:"PURSUANT TO TITLE III OF THE SUPERFUND
AMENDMENTS & REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372, THIS PRODUCT CONTAINS OR MAY CONTAIN A TOXIC CHEMICAL IN A
QUANTITY SUBJECT TO THE REPORTIN G REQUIREMENTS UNDER SECTION 313".